Effects of protease enzyme supplementation in weanling pigs’ diet with different crude protein levels on growth performance and nutrient digestibility

The protease enzyme used in this study was a commercial product purchased from (Ronozyme ProAct^®, Novozymes A/S, Bagavaerd, Denmark) synthesized from Bacillus licheniformis submerged fermentation.

In the 5-weeks of the experiment, a total of a hundred crossbred [(Landrace × Yorkshire) × Duroc] weanling pigs were assigned to one of four dietary treatments based on the average initial body weight (BW) of (7.17 ± 1.06 kg) and sex. They were then divided into 5 replications, with each pen containing 5 pigs (3 gilts and 2 castrated barrows) in a randomized complete block design. The nutritional diets were provided in two distinct phases, phase 1 (0 to 14 days) and phase 2 (15 to 35 days). The dietary treatments were as follows:

Phase 1: CON: basal diets (20.60% CP); low protein (LP): CON - 0.30% CP; PLP1: (CON − 0.30% CP) + 0.05% protease; PLP2: (CON − 0.50% CP) + 0.05% protease.

Phase 2: CON: basal diets (18.88% CP); LP: CON − 0.30% CP; PLP1: (CON − 0.30% CP) + 0.05% protease; PLP2: (CON − 0.50% CP) + 0.05% protease.

The basal diets were prepared following National Research Council (NRC) standards and were designed to meet or exceed the nutrient requirements of pigs [17]. The dietary composition of weanling pigs utilized in this experiment is illustrated in Table 1. The room temperature was kept at 28°C, and each pen was outfitted with a self-feeder and nipple drinker, allowing the weanling pigs’ free access to feed and water throughout the research.

To compute the growth performance, the individual piglet’s BW was measured using a GL-6000S balance machine (G-Tech International, Uijiengbu, Korea) on days 14 and 35 to determine the average daily gain (ADG). Meanwhile, the amount of feed ingested and feed residues (on a per-pen basis) were recorded to calculate the average daily feed intake (ADFI) and feed conversion ratio (FCR).

Seven days before fecal sample collection, 2 g/kg of indigestible marker chromium oxide (Cr₂O₃) was added to weanling pig diets to determine nutrient digestibility of nitrogen (N), DM, and GE. Fresh fecal samples were collected by qualified personnel at the end of week 5 from two pigs per pen (1 gilt and 1 barrow) using a rectal massage technique, immediately placed in an ice box, delivered to the laboratory, and maintained at −20°C until examined. Then the samples were dried for 72 hours in a forced-air oven at 70°C before being finely powdered to pass through a 1-mm screen sieve. The AOAC recommended procedures were used to analyze the DM. UV absorption spectrophotometry was used to determine the amount of chromium in the sample (UV-1201, Shimadzu, Kyoto, Japan) and the findings were recorded for statistical analysis. 2 grams of feed and fecal sample were measured and assigned in an oxygen bomb calorimeter Parr 6400 to calculate GE (Parr Instrument Company, Moline, Il, USA). A Kjeltec 8600 analyzer was used to determine the N content (Foss Tecator AB, Hoeganaes, Sweden). The following formula was used to calculate the nutrient digestibility: N digestibility = 1 − [(Nf × Cd) / (Nd × Cf)]; N – nitrogen, Nf – nutrient concentration in feces, Nd – nutrient concentration in diet, Cd – chromium concentration in diet, and Cf – chromium concentration in feces.

The data from the experiments were cleaned and exported to SAS software (SAS Institute, Cary, NC, USA) for analysis. They were analyzed using a completely randomized block design by using SAS’s Generalized Linear Model procedure. The pen was regarded as the experimental unit. The GLM approach was used to assess significant differences in mean values among dietary treatments using repeated measurements and Duncan’s tests. The standard error means were used to express data variability. Probabilities less than 0.05 were deemed significant.

Table 2 displays the growth performance data. The findings indicated that the inclusion of protease in low CP diets enhanced the weanling pigs’ BWG (p = 0.046), ADG (p = 0.049), FCR (p = 0.039), and ADFI tended to increase (p = 0.053) during phase 1. However, FCR tended to increase (p = 0.076) throughout the experiment but was not affected during phase 2, and also BW, ADG, and ADFI remained unaltered throughout phase 2 and overall.

The nutrient digestibility of N, DM, and GE is illustrated in Table 3. Dietary protease supplementation in weaned pigs with low CP had no effect on N, DM, and GE on nutrient digestibility in all phases and overall. However, the addition of protease to the low CP diets increased tendency of N digestibility (p=0.059) during phase 1.

Exogenous protease enzyme supplementation to the diets to promote protein usage has attracted the pig industry’s interest. Generally, dietary protease has been utilized as a mono-component or as part of an enzyme combination in poultry and swine diets [13,18]. Protein is required for the metabolism and physiology of animals, and changing CP levels in isoenergetic diets, on the other hand, is linked to changes in energy-to-protein ratios, which can have a big impact on body composition such as body fat content [19]. Exogenous enzymes should be studied because they have been found to assist lower the amount of nutrients in animal diets, especially CP. Various researchers have reported that the inclusion of protease in the diet of swine can enhance their growth performance. Protease supplementation increased ADG and G: F ratio (p < 0.05) in finishing pigs fed a protease-supplemented diet during weeks 6–12 [20]. Moreover, Lei et al. [21] reported that supplementing protease to a low CP diet increased growth performance. In the current study, weanling pigs fed low CP diets and treated with protease had better BW, ADG, and FCR during phase 1, and also the ADFI tended to increase when protease was added to the weaned pigs’ diets. Contrary to expectations, this study found no significant differences in growth performance between the four groups during phase 2 or throughout the trial. The release of endogenous enzymes is lower in younger animals due to post-weaning stress or a lack of solid feed intake after weaning [22]. As a result, young animals are more responsive to exogenous enzyme supplementation, which is likely why phase 1exhibited such a great positive result. Although these findings differ from those of some previously published studies [9,23], they are consistent with a study conducted on broiler chickens by Yan et al. [24] who found that supplementing protease to broiler chickens’ diet during the starter phase had a stronger effect than during other growth phases. Moreover, the current study’s findings are consistent with those of Lei et al. [21], who discovered improved growth performance in finishing pigs fed protease-supplemented diets. Further research on the effect of protease on pig growth performance is needed to resolve the inconsistencies in available data.

Protease is recognized as a dietary enzyme that aims to increase protein availability by targeting tight protein binding. Protease improves protein digestibility by hydrolyzing proteins into free amino acids and peptides that can be absorbed in the small intestine [25]. Protease supplementation has been shown to improve performance in both normal and reduced protein diets [26]. In the current experiment, we discovered that protease had no effect on N, DM, and GE on the nutrient digestibility in either each phase or overall. The lack of effect of the supplemented protease in the second phase could be attributed to the post-weaning phase, where pancreatic protease secretions were in an exponential phase [18] and the endogenous enzyme metabolism could have reduced the activity of the supplemented protease. However, adding protease to the low CP diets, increased the tendency of N digestibility during phase 1. This negative nutrient digestibility response in the current study could be attributed to the substrate released by the enzyme, which may have been used by commensal bacteria rather than the pig’s metabolism, as improvements in nutrient digestibility do not always translate to significant increases in metabolic energy. Although many prior studies claimed considerable improvements in nutrient digestibility [11,27–29]. For example, Tactacan et al. [11] discovered that pigs fed the protease diet had higher apparent total tract digestibility of DM and N (p < 0.05) than pigs fed the CON diet. In addition, Guggenbuhl et al. [18] found that dietary serine protease generated by B. licheniformis fermentation increased apparent ileal amino acid digestibility in weaned piglets. However, other research studies produces the results that are consistent with our current findings. For instance, Mohammadigheisar and Kim [9] discovered that the addition of dietary protease did not affect N digestibility. It is possible that young animals are more sensitive to supplemental protease, in agreement with the findings of this study.