INTRODUCTION
Corn and soybean meal (SBM) are feed ingredients that are commonly used to fulfill the energy and amino acid (AA) requirements of poultry and account for more than 70% of broiler diets. Broilers’ feed costs are highly dependent on the costs of these two major ingredients and affect demand and supply in broiler production [1]. The supplementation of diets with appropriate amounts of dietary protein and AA is directly correlated with broilers’ body protein accretion and growth performance [2,3]. Diets formulated with digestible AA to provide balanced dietary AA would ensure the growth of broilers [4]. Therefore, to achieve better growth performance and feed efficiency, it is important to accurately determine the digestible AA concentration in feed ingredients employed in feed formulations [5]. The standardized ileal digestibility (SID) of AA is considered as the most reliable value to obtain accurate values of the level of digestible AA in single feed ingredients or mixed diets [6,7]. Because the SID of AA is more additive in the mixed diet than the apparent ileal digestibility (AID), the SID of AA is widely used to express the digestible AA in diets for broilers [5,8,9].
The gastrointestinal integrity in broiler chickens increases with age, which improves the capability of nutrients digestion and absorption [10,11]. To accurately formulate diets to achieve appropriate amounts of nutrients for the different growth stages of broilers, the digestible AA at age-appropriate values should be used. However, there are limited data for AA digestibility values for young broilers or on comparisons of AA digestibility between broilers of different ages. Therefore, in this study, SID and AID of AA in corn and SBM for 10- and 22-d-old male broilers were determined.
MATERIALS AND METHODS
The protocols for the present study were reviewed and approved by the Institutional Animal Care and Use Committee at Kyungpook National University (KNU2020-0066).
The analyzed crude protein (CP) and AA compositions in corn and SBM used in the present study are shown in Table 1. Tables 2 and 3 present the ingredient compositions and analyzed AA compositions of the experimental diets used in experiment 1, respectively. The ingredients compositions and analyzed AA of the experimental diets used in experiment 2 are presented in Tables 4 and 5, respectively. The analyzed AA compositions in the experimental diets were close to the calculated values. A nitrogen-free diet (NFD) was formulated to estimate the basal endogenous losses (BEL) of AA. Two of three diets were formulated to contain either corn or SBM as the sole source of AA. All dietary energy and nutrient contents met or exceeded the recommended requirements for broilers, except CP and AA. All diets contained 0.5% chromic oxide as an index for calculating digestibility.
SBM, soybean meal; AA, amino acids; Arg, arginine; His, histidine; Ile, isoleucine; Leu, leucine; Lys, lysine; Met, methionine; Phe, phenylalanine; Thr, threonine; Val, valine; Ala, alanine; Asp, aspartic acid; Cys, cysteine; Glu, glutamic acid; Gly, glycine; Pro, proline; Ser, serine; Tyr, tyrosine.
Provided per kg of diet: vitamin A, 9,000 IU; vitamin D, 4,000 IU; vitamin E, 50 mg; vitamin K3, 2.5 mg; thiamine nitrate, 2.0 mg; riboflavin, 6.0 mg; pyridoxine hydrochloride, 3.0 mg; vitamin B12, 0.013 mg; nicotinic acid, 50.0 mg; calcium pantothenate, 15.0 mg; folic acid, 1.5 mg; biotin, 0.1 mg; Mn, 96 mg as manganese sulfate; Zn, 90 mg as zinc sulfate; Fe, 50 mg as ferrous sulfate and ferric oxide; Cu, 24 mg as cupric sulfate; I, 1.2 mg as calcium iodate; Se, 0.36 mg as sodium selenite.
NFD, nitrogen-free diet; SBM, soybean meal; AA, amino acids; Arg, arginine; His, histidine; Ile, isoleucine; Leu, leucine; Lys, lysine; Met, methionine; Phe, phenylalanine; Thr, threonine; Val, valine; Ala, alanine; Asp, aspartic acid; Cys, cysteine; Glu, glutamic acid; Gly, glycine; Pro, proline; Ser, serine; Tyr, tyrosine.
Provided per kg of diet: vitamin A, 9,000 IU; vitamin D, 4,000 IU; vitamin E, 50 mg; vitamin K3, 2.5 mg; thiamine nitrate, 2.0 mg; riboflavin, 6.0 mg; pyridoxine hydrochloride, 3.0 mg; vitamin B12, 0.013 mg; nicotinic acid, 50.0 mg; calcium pantothenate, 15.0 mg; folic acid, 1.5 mg; Biotin, 0.1 mg; Mn, 96 mg as manganese sulfate; Zn, 90 mg as zinc sulfate; Fe, 50 mg as ferrous sulfate and ferric oxide; Cu, 24 mg as cupric sulfate; I, 1.2 mg as calcium iodate; Se, 0.36 mg as sodium selenite.
NFD, Nitrogen-free diet; SBM, soybean meal; AA, amino acids; Arg, arginine; His, histidine; Ile, isoleucine; Leu, leucine; Lys, lysine; Met, methionine; Phe, phenylalanine; Thr, threonine; Val, valine; Ala, alanine; Asp, aspartic acid; Cys, cysteine; Glu, glutamic acid; Gly, glycine; Pro, proline; Ser, serine; Tyr, tyrosine.
Two experiments were conducted. Both experiments used the same experimental design and protocol, but male boilers of different ages were used (Exp. 1: 7–10 d; Exp. 2: 18–22 d). Four hundred and eighty (age = 7 d; initial body weight [BW] = 173.4 ± 12.65 g) and 192 (age = 18 d; initial BW = 772.2 ± 62.13 g) Ross 308 broilers were allocated to the three dietary treatments in a randomized complete block design with eight replicate cages per treatment using the Experimental Animal Allotment Program [12]. In Exp. 1, from 1 to 7 d of age, all birds were fed the experimental diets ad libitum for 3 days. In Exp. 2, day-old birds were fed a commercial starter diet with 20% CP from d 1 to 18 days of age. Birds were provided ad libitum access to water and feed during the experimental periods. The experimental environment was controlled with continuous light and temperature conditions. Birds were housed in wire-floored cages in an environmentally controlled room at 33°C for the first 3 d, and then the temperature was gradually decreased to 24°C at d 22, in accordance with Ross broiler recommendations, after which it was maintained until the end of the experiment.
On 10 and 22 d in Exps. 1 and 2, all birds were euthanized by CO2 asphyxiation. Ileal digesta was collected from the distal two-thirds of the ileum (the portion of the small intestine from Meckel’s diverticulum to approximately 1 cm anterior to the ileocecal junction) by rinsing the samples with distilled water [13]. Ileal digesta samples from 20 and 8 birds within a cage for Exps. 1 and 2 were pooled, respectively. Collected ileal samples were stored in a freezer at −20°C for further analyses.
The ingredients and experimental diet samples were dried at 135°C for 2 h in accordance with method 930.15 of AOAC International [14] and ground using a mill grinder (CT 293 Cyclotec, Foss, Hamburg, Germany). Freeze-dried ileal digesta samples were ground using a coffee grinder. The dried samples of the ingredients, diets, and ileal digesta were analyzed for AA content using method 982.30 of AOAC International [14], except for Trp. Dried diets and ileal digesta samples were analyzed for chromium content using the method described by Fenton and Fenton [15], which was used in calculating ileal digestibility.
The AID, BEL, and SID of the AA were calculated using the following equations from Kong and Adeola [5]:
where Crdiet (g/kg) and Crdigesta (g/kg) are the chromium concentrations of the diet and digesta on a dry matter (DM) basis; and AAdiet (mg/kg of DM) and AAdigesta (mg/kg of DM) are the AA concentrations of the diet and digesta on a DM basis, respectively.
Data were analyzed using the MIXED procedure in SAS software (SAS 9.4, SAS Inst, Cary, NC, USA). The experimental unit was a cage. Dietary treatments were considered as a fixed variable, and the block (replication) was considered as a random variable. The AID and SID values for corn and SBM were presented as the least squares mean. Contrasts were used to determine the main effects of age (10 vs. 22 d) and feed ingredients (corn vs. SBM) and the interaction between these two main effects. The significance was set at α = 0.05.
RESULTS
The values for the AID of AA in corn and SBM for broilers between 10- and 22-d-old male broilers are presented in Table 6. There was an interaction (p < 0.05) between the age of birds (10 vs. 22 d) and feed ingredients (corn and SBM) for the AID of most AA, except for methionine (Met), valine, cysteine (Cys), and Tyr. The AID of AA, except for leucine (Leu) and Cys of birds fed a corn-based diet, was lower (p < 0.05) than the values of birds fed an SBM-based diet, regardless of the age of the birds. Estimated AID of indispensable AA in corn for 10- and 22-d-old male broilers ranged from 49.4% (threonine [Thr]) to 80.5% (Met) and 68.2% (Thr) to 89.9% (Leu), respectively. In addition, estimated AID of indispensable AA in SBM for 10- and 21-d-old male broilers ranged from 73.5% (Thr) to 88.0% (arginine [Arg]) and 81.2% (Thr) to 92.2% (Arg), respectively. The estimated AID of all AA for 22-d-old male broilers was greater (p < 0.05) than the values for 10-d-old male broilers, regardless of the type of feed ingredient. Table 7 presents the BEL of AA for 10- and 22-d-old male broilers fed NFD. The BEL values of all indispensable and dispensable AA values for 10-d-old broilers were greater (p < 0.05) than those for 22-d-old birds.
SBM, soybean meal; AA, amino acids; Arg, arginine; His, histidine; Ile, isoleucine; Leu, leucine; Lys, lysine; Met, methionine; Phe, phenylalanine; Thr, threonine; Val, valine; Ala, alanine; Asp, aspartic acid; Cys, cysteine; Glu, glutamic acid; Gly, glycine; Pro, proline; Ser, serine; Tyr, tyrosine.
Values were determined using the pooled samples from eight replicate cages of 20 and 5 birds per cage for 10- and 21-d-old male broiler chickens.
DMI, dry matter intake; AA, amino acids; Arg, arginine; His, histidine; Ile, isoleucine; Leu, leucine; Lys, lysine; Met, methionine; Phe, phenylalanine; Thr, threonine; Val, valine; Ala, alanine; Asp, aspartic acid; Cys, cysteine; Glu, glutamic acid; Gly, glycine; Pro, proline; Ser, serine; Tyr, tyrosine.
The SID of AA values in corn and SBM for 10- and 22-d-old male broilers are presented in Table 8. For the SID of AA, there was an interaction (p < 0.05) for only histidine, isoleucine, Leu, phenylalanine, alanine (Ala), and glutamic acid (Glu) values between the age of the birds and ingredients. The trends of the effect of age on the AA digestibility were maintained and the effect of ingredients on AA digestibility were similar to the AID of AA values. The SID of AA, except for Leu, Ala, Glu, and proline, in corn were lower (p < 0.05) than the values in SBM, regardless of age. The estimated SID of indispensable AA in corn for 10- and 22-d-old male broilers ranged from 71.8% (Thr) to 86.0% (Met) and 81.8% (Lys) to 92.8% (Leu), respectively. In addition, estimated SID of indispensable AA in SBM for 10- and 21-d-old male broilers ranged from 81.4% (Thr) to 89.8% (Arg) and 86.8% (Thr) to 93.4% (Arg), respectively. Similar to the result of the AID of AA, the estimated SID of all AA for 22-d-old male broilers was also greater (p < 0.05) than the values for 10-d-old male broilers, regardless of the type of feed ingredient.
DISCUSSION
Several studies demonstrated that the utilization of nutrients can be influenced by the age of birds [10,11,16] In addition, the digestible AA varies on the feed ingredients [17,18]. Therefore, the determination of AA digestibility of broilers in different growth stages can help formulate accurate feed formulation with digestible AA of birds. The aim of the present study was to evaluate the AA digestibility of corn and SBM in different ages of broilers commonly used in poultry diet.
Similar trends were observed in the SID of AA in corn and SBM in response to the age of the birds. However, the impact of age on AID and SID of corn was greater than that of SBM, which might be attributable to the low absolute amount of digestible AA due to the low AA concentration in corn and low feed intake in young broilers. The discrepancy in AA digestibility among ingredients diminished with advancing age of the birds, which might be attributable to the greater contribution of BEL of AA in corn than that of SBM, and greater amounts of BEL in younger than in older birds [19,20]. A greater contribution of BEL in diet with a low level of CP (i.e., corn) than in that with a high level of CP (i.e., SBM) is well accepted in various studies [6,7]. For this reason, a reduced interaction effect in the SID of AA is partially explained by the reduced contribution and amount of BEL of AA in the test ingredients with age.
In the present study, the AID and SID of AA in corn and SBM improved as the age of the chickens increased. The ileal AA digestibility was higher in 22-d-old than in 10-d-old birds. Huang et al. [11] reported the AID of AA in corn and SBM for 14-, 28-, and 42-d-old broilers. In their study, the ranges of average AID of AA in corn and SBM for 14- and 28-d-old broilers were 79.0% to 83.3% and 85.1% to 87.9%, respectively. These values are close to those obtained in the present study. Several researchers have found that the digestibility of protein and AA is age-dependent [11,16,17,21]. The availability of dietary energy [16], protein, and AA [11,16,17,21] is lower in newly hatched birds (from 1- to 10-d-old) than that in mature ones. Increased digestibility of AA with age might be explained by improved digestive enzyme activities [10,22,23]; increased AA absorption results in morphological development of the digestive tract [10,22,23]. In previous studies, the activities of intestinal lipase, pancreatic amylase and lipase, trypsin, and intestinal amylase were found to peak at 4, 8, 11, and 17 d old, respectively [22]. In addition, Noy and Sklan [10] reported increased activities of digestive enzymes, including amylase, trypsin, and protease, between 4 and 21 d of age. Using a broken-line analysis, Batal and Parsons [16] found that total tract digestibility of energy and Lys of birds peaked at 14 and 10 d of age, respectively.
In the present study, the values of AID of AA in corn and SBM in 10- and 22-d-old birds were low for Thr (49.4% and 68.2% in corn and SBM for 10 d of age; 73.5% and 81.2% in corn and SBM for 21 d of age) and high for Met (80.5% and 87.9% for 10 d) and Arg (88.0% and 92.2% for 21 d), respectively. Although the availability of dietary AA increased with advancing age of birds, similar results have been reported by previous studies [6–8,25]. The composition of protein and AA in feed ingredients varies with the plant origin of the feed ingredient. Thus, the effect of the age of birds on AA digestibility may reasonably be influenced by the nutritional composition of the feed ingredients, the presence of antinutritional factors, and different processing methods. Huang et al. [11] compared the effects of age on the AID of AA in eight feed ingredients (wheat, sorghum, corn, SBM, canola meal, cottonseed meal, meat and bone meal, and mill run) used for poultry diets. The AA digestibility in most feed ingredients, except for cottonseed meal, showed increments with the advancing age of birds [11]. The processing of cottonseed meal, including heat and extraction treatments and the presence of an antinutritional factor, such as gossypol, alters the chemical composition of feed ingredients, resulting in nondigestible AA that cannot be broken down by digestive enzymes [11,20]. This indicates that, despite the improvements in digestive function with age, chemical and physical properties of feed ingredients still influence digestible individual AA in feed ingredients. However, in this study, the impact of the age of birds (10- and 21-d-old) was greater than that of the type of feed ingredients (in this case, corn and SBM) on the ileal AA digestibility of male broilers.
In conclusion, with advancing age of the birds, there was an increase in digestible AA concentration in corn and SBM. Our findings suggest that the levels of ileal AA digestibility in corn and SBM commonly used in poultry diets are influenced by the age of the birds and the characteristics of the feed ingredients.
